- Volvo Penta XDP-B Drives Upgrade Question
Dear sir or madame,
I’m an owner of a Monterey 322 with faulty Volvo Penta XDP-B drives. I’ve seen on your blog, that Volvo extended the ...
- Volvo Penta XDP-B drives question
Hello Sir:
We have done this upgrade with people overseas (I just sent one off to Hong Kong).
Volvo Penta has now extended this to February 15th so ...
- Volvo Penta 2002 question
Hello:If you have a 2002 with a serial number below 2300046825 then you need to go with 21134777 pump and the new pipe 840001.If you ...
- Volvo Synthetic Diesel Oil Question
Hello Sir:I did not order this yet as you asked for the engine oil 1141626 which turns into 40005015. This is synthetic diesel oil and Volvo ...
- Volvo PN 3588865 Fuel Pump Question
Hello Sir:The 3588865 fuel pump is just the high pressure pump for the fuel cell. I can supply this. But Volvo Penta strongly recommends that ...
- Volvo Kit to Analyze Antifreeze Question
Good morning.
I work with volvo penta engines. I would like to know if you have any kit to analyze the antifreeze (green). In the manual brand to analyze but I have no benchmarks. The engine that we use on board isthe C D16 to MG.
**********************
Hello:
You can pick up a Specific gravity ...
- Volvo Expired Seawater Pump Question
Hello:I am sorry, but the 3587508 seawater pump has gone obsolete . Volvo Penta no longer offers the pump.I do have a source for one ...
- Volvo Expired Hoses Question
Hello:
You ordered two expired hoses 3860019 and 3860298. They have been expired quite awhile I can probably get these for you (or an equivalent ones), ...
- Volvo MD2040 Seals Question
Hello Mr Neeson,i have 2 Volvo MD2040 with Volvo saildrives on my catamaran . The engines are 13 years old (2300 hours each) and i ...
- Volvo 3852692 Push Rod Expired Question
Hello Sir:The 3852692 is an expired gasket. I don't have one, but I did find one, but note the price is much higher.The push rods ...
- Volvo Universal Joint 3841481 RPL 22197130 Question
Hi,I already received the package but inform you that the bellows kit is not referred brand Volvo Penta and is not even for the model ...
- Volvo Penta Pump Part Number 21608512 Question
Thanks for the prompt response. The part number that I was given is 3594785. I do not need a ethanol resistant pump, as the marinas ...
- Volvo Sealant 1161099 Expired/ Permatex #3 Question
Hello Sir:The sealant 1161099 is no longer available from Volvo Penta.However, Volvo Penta mentioned, in one of their service manuals, that youcan use Permatex #3 ...
- Verado Model Question
Hello:If you give me your Verado mode; (it looks like this is what it is) and the serial number (if you have it), I can confirm ...
- Volvo PN 3803309 Back Order Question
Hello:The head 3803309 is on long term back order at Volvo Penta. I talked with Volvo Penta last Friday and they told me that the leadtime ...
- Volvo Damper 3884460 Question
Hello Sir:
Your original damper was a 3860981 which Volvo Penta superceeded to a 3884460 which is no longermanufactured by Volvo Penta. I called Volvo Penta and they ...
- Volvo Penta 875697/21651364 Question
Hello:Volvo Penta got back to me about the difference between the earlier number 875697 and the 21651364. Both of them have the same impeller and the ...
- Volvo Penta 2003T Turbo Question
Volvo Penta 2003TOk, I looked up the turbo price. Im better now but still a little weak. I have two "cores" one in worse shape ...
- Volvo 873531 RPL 22314183 Question
Hello:
Volvo Penta is still having some issues on these, but they have contacted with a new
vendor for this part. This means there is a new ...
- Volvo Head 26430693 Question
Hello Sir:I am sorry, but the head (26430693) for your fuel injection pump is obsolete. The entire pump (that includes the head), fuel inj. pump 37740, is also ...
- Volvo DP-H Prop Shaft Question
Hello:
I am sorry, but the prop shafts on the DP-H drives are unique enough that I can't offer an
alternative to the G props.
From time to ...
- Volvo AQ170 Aftermarket Tach Set Question
Hello:Attached is a quote for the swapping of the pump from the one with the tach sensor in it to the other pump. This should work, ...
- Volvo PN 838697 Replacement Question
Hello,
What is the exchange part # for Volvo part # 838697. EPC says there one available for this but I am having trouble locating it.
Thanks,
*********************************************
There ...
- Volvo TAMD41 Compressor Question
Hello!I stand AD41 two engines(TAMAHA SC32) if you have parts to upgrade the KAD42. It compressors with accessories, Thanks
******************************
Hello Sir:If I understand, you want to ...
- Volvo Consumer Affairs Question
Hi JD,
We have purchased a couple of ECU's for our volvo engine from you.
We are located in Mexico and our local Volvo dealer is letting ...
- Volvo Penta 3807943 Prop Blades Expired Question
Hello:I am sorry, but the 3807943 X4 blades are no longer available from Volvo Penta. I looked around and was unable to find anyone who has this ...
- Volvo PN 3803543 Replaced by 3801641 Question
Hello Sir:As we talked on the phone, Volvo Penta says both the original 300 head 3803543 is superseded by a 3801641. The 3801641 is supposed to ...
- Volvo D4-300, D4-300D-B Question
Dears,
I need a few parts for my Volvo D4 300. I was wondering if you could be so kind to provide the full schematics for my ...
- Volvo Penta Part Number Suffix Question
Dear Sir,
These are also for Volvo Penta. I have a major request for clarification. All my part numbers have a digit after a (Dash - ) ...
- Volvo 3807943 Plastic Prop Blades NLA Question
Hello:I am sorry, but the plastic props 3807943 are no longer available. I have not been able to find anyone who has these. However, I can supply ...
- Volvo 839330 and 839331 Expired Question
Hello Sir:We received your order for the parts 839330 and 839331. Both parts are expired, but I do have a source for them.Attached is a quote ...
- Volvo 945444 Flange Bolt Question
Hello Sir:
Thank you for getting back to us.
The 945444 flange bolt for the exhaust is an error in the Volvo Penta system. When you actually ...
- Volvo D3-200 PCU and Velvet Drive Transmission Questions
Hello Sir:Attached is a quote for the PCU that probably goes with your D3-200. I say probably, because without the serial number of the engine, I ...
- Volvo 3862228 RPL 3847644 and Bulletin Questions
Hello:I recently purchased Volvo Penta p/n 3862228 (fuel filter) not realizing there was a Volvo Penta Bulletin calling for another part # for a higher ...
- Volvo Engine Fresh Water Flush Kit Question
Volvo Penta 1989 5.7 L engine with fuel injection...it uses 2 belts on front of engine 06484 - I know there is an engine fresh water ...
- Volvo 31-44 Installation Instructions Question
Hello:
Here are the installation instructions.
J.D. ...
- Volvo Steering Pump 855860 Now 855872 Question
Hello:
The new steering pump 855872 is a direct replacement for power steering pump 855860. However, 855860 had a pulley that was held on by 4 ...
- Volvo 165 (1000 HP), ZF or Twin Disc Gear similar to ZF 550A Question
Howdy JD,
I called you regarding a freewheeling screw (ZF550A) while the other engine/screw is rotating approx. 4.5 knots for about an hour. I called ...
- Volvo Penta AD41D Diesel Injector Question
Volvo Penta AD41D dieselNeed to know the difference between your two parts listed as injectors for the Volvo Penta AD41D diesel: 861103 and 3803238 which run ...
- Volvo Penta KAD42P-A Head Bolt Reuse Question
Volvo Penta KAD42P-AWould like know how many times you can reuse the headbolts
Thank you,
C.
*********************************
Hello:
By the manual you are not supposed to use the headbolts more ...
- Volvo Part 854934 Now 21389074 Question
Hello Sir:
Attached is a diagram of the upper unit of the sail drive. Ref. 70 is the big rubber seal that is squeezed between the ...
- Volvo Penta 3.0 1999 Riser Question
Hello Sir:
Attached is a Volvo Penta schematic showing that your 3.0 1999 engine uses a riser 3857798,
The attachment showing 3857798 shows the Volvo Penta system page ...
- Volvo 165 (1000 HP), ZF or Twin Disc Gear similar to ZF 550A Question
Howdy JD,
I called you regarding a freewheeling screw (ZF550A) while the other engine/screw is rotating approx. 4.5 knots for about an hour. I called ...
- Volvo 873531 RPL 22314183 Question
Hello:
Volvo Penta is still having some issues on these, but they have contacted with a new
vendor for this part. This means there is a new ...
- Volvo Part 854934 Now 21389074 Question
Hello Sir:
Attached is a diagram of the upper unit of the sail drive. Ref. 70 is the big rubber seal that is squeezed between the ...
- Volvo 839330 and 839331 Expired Question
Hello Sir:We received your order for the parts 839330 and 839331. Both parts are expired, but I do have a source for them.Attached is a quote ...
- Volvo PN 838697 Replacement Question
Hello,
What is the exchange part # for Volvo part # 838697. EPC says there one available for this but I am having trouble locating it.
Thanks,
*********************************************
There ...
- Volvo Steering Pump 855860 Now 855872 Question
Hello:
The new steering pump 855872 is a direct replacement for power steering pump 855860. However, 855860 had a pulley that was held on by 4 ...
- Volvo 873531 RPL 22314183 Question
Hello:
Volvo Penta is still having some issues on these, but they have contacted with a new
vendor for this part. This means there is a new ...
- Volvo Penta sterndrive alignment tool is it the same one used on Mercruiser? thanks
Hello:
The alignment tools are not exactly the same. Same principle and they look alike, but the ends (where it goes into the
coupler) is just ...
- Volvo trans HS45AE-C
Hi Folks- I ordered both a cable connection and filter for the above transmission and then went in for a hernia operation (yikes!). For sure, the cable connection is not compatible with the solenoid on the trans which appears to be 2, 1/4" spade connectors. I checked with volvo and ZF and the superceding number 22769770 is what is shown but does not fit. I would like to return if possible and hopefully order the correct connection or harness? I can send pics if that helps identify the part. My invoice number is 295671. Thanks a bunch, Blaine
Hello:
What has happened is that Volvo Penta (and ZF Marine) have changed the solenoids from 874097 (ZF #3312 308 064) to 22774568 (ZF#3312 308 183). ...
- VOLVO PENTA 270 ENGINE 1984 BAYLINER 28 FT Contessa
I Would like a price on a complete outdrive single prop both new and re-built. Please advise if you need a picture or more information. Thank You Tom
Hello:
We need the serial number to identify the ratio.
There should be a serial number on the drive starting with “27xxxxxxx” and then often a letter ...